濟南飼料機械廠
聯系人：安經理
手機：152-5313-4653
郵箱：347299818@qq.com
地址：濟南市濟北開發區
1、作業后，應及時將機內、水箱內、管道內的存料、積水放盡，并清潔保養機械，清理工作場地，切斷電源，鎖好電閘箱。
After the operation, the machine should be promptly, within the tank, storage material inside the tubes, water exhausted, and cleaning and maintenance machinery, cleaning up the work site, cutting off power, lock gates boxes.
2、儀表、指示信號準確可靠，電動攪拌機的操縱臺應墊上橡膠板或干燥木板。
Meter indicating signal is accurate and reliable electric mixer console should mat rubber sheet or dry wood.
3、傳動機構、工作裝置、制動器等，均應緊固可靠，保證正常工作。
Transmission, work, brakes, etc., should be securely tightened to ensure the normal work.
4、骨料規格應與攪拌機的性能相符，超出許可范圍的不得使用。
Aggregate performance specifications should be consistent with the mixer, beyond the scope of the license may not be used.
5、空車運轉，檢查攪拌筒或攪拌葉的轉動方向，各工作裝置的操作、制動、確認正常，方可作業。
Running empty, check the rotational direction of the mixing tube or stirring the leaves, the operation of the working device, the brake confirm normal operation only.
6、進料時，嚴禁將頭或手伸入料斗與機架之間，運轉中不得用手或工具等物伸入攪拌筒內扒料出料。
The feed is prohibited between the head or hand into the hopper and rack operation shall not stir hand or tools, such as stretching the material feeding tube steak.
7、料斗升起時，嚴禁在其下方工作或穿行。料坑底部要設料斗的枕墊，清理料坑時必須將料斗用鏈條扣牢。
When the hopper is raised, is prohibited under or walk through in their work. Expected to be set at the bottom of the hopper pit pillows, must be anchored with a chain when cleaning the hopper pit material.
8、向攪拌筒內加料應在運轉中進行；添加新料必須先將攪拌機內原有的飼料全部卸出后才能進行。不得中途停機或在滿載時啟動攪拌機，反轉出料者除外。
The mixing tube feeding should be in operation; adding new material must first after the original concrete mixer can be discharged within the whole. Can not stop or start blender halfway when fully loaded, except reverse the material.
9、作業中，如發生故障不能繼續運轉時，應立即切斷電源，將攪拌筒內的飼料清除干凈。
Operations, such as the failure can not continue to operate, they should immediately cut off the power to stir the concrete barrel cleaned.
10、作業后，應對攪拌機進行全面清洗，操作人員如需進入筒內清洗時，必須切斷電源，設專人在外監護，或卸下熔斷器并鎖好電閘箱，然后方可進入。
After the operation, a comprehensive response to the mixer cleaning, the operator enters the cylinder when additional cleaning, you must cut off the power, let someone out custody, and locked gates or remove the fuse box, and then allowed to enter.
11、作業后，應將料斗降落到料斗坑，如須升起則應用鏈條扣牢。
After the operation, the hopper should drop into the hopper pit, then the application must be raised as a chain anchored.